Welcome to The Australian Hayabusa Club Forum - ARCHIVE ONLY VERSION - NEW REGISTRATIONS & POSTS DISABLED › Bike Discussions › General Discussion v
Hello from HeavyBusRacing

Hello from HeavyBusRacing
SRADkneedragger
Guest
 
#138
20-04-2010, 06:41am
OOOH! AHHH! that looks NICE!
This view shows you where we put the fuel pump and fuel filter, pretty much a perfect fit in the valley on top of the Transmission. It was wrapped in closed cell foam to protect it from heat and vibration.
[Image: P1010255.jpg]
If you look at the #2 cylinder nozzle in this picture this shows how careful you have to be with planning. We tried to keep the mounting positions all similar. When we got to #2 (We were working from the R to L) we drilled the hole and tapped it and discovered the Nozzle wouldn't screw in! The hose fittings were just about 1/16th of an inch to wide and hit the bulge for the thermostat housing!
[Image: P1010258.jpg]
No sweat right? Just unscrew the fittings from the nozzle screw it in then screw in the fittings.
[Image: P1010184.jpg]
WRONG! turns out the hose fittings are brass and the Nozzles are aluminum and they are put together with a locktite thread sealer, and before you can flinch it twisted off!
OH did I mention this was Saturday night about 10pm? Exactly 1 week before the races! Well while SRAD is wringing his hands, I pick up the phone and Call Mike at Nitrous Express(Yes I have cell phone numbers, yes they said call ANYTIME, yes this was pretty desperate) No sweat a new Nozzle showed up Tuesday morning!
Next up was the install of the electrics. Nitrous Express set me up with one of their 2 dial Digital Nitrous Controllers.
[Image: P1010262.jpg]
This is really the heart of this setup. Without it I would hit the button and the system would dump 100hp worth of fuel and nitrous instantly and the tire isn't going to like that at all!
With the Digital Controller you can control what %age of your total hp jetting that the Nitrous starts off at. For instance if your jetted for 100hp and set the Digital Controller to come on at 25% it will start out with a 25hp spray. From what I understand it works by fluttering the solenoids open and closed very fast, allowing only 25% of the total volume to pass. It also controls the "ramp" or the amount of time it takes for the system to increase the hp until it reaches the full amount it's jetted for.
So keeping the #'s easy you could jet for 100hp, hit the gas, it comes on at 25%(25hp) and increases over 3 seconds to 100%(100hp).
Now everything is adjustable from starting %age to length of time to full power. Pretty cool huh?
Finally! Something I can do! I work with electronics all day building electric vehicle controllers so this is easy! As a bonus the instructions are pretty clear.
[Image: P1010267.jpg]
Reply


Messages In This Thread
Hello from HeavyBusRacing - by SRADkneedragger - 18-01-2009, 04:12am
RE: Hello from HeavyBusRacing - by SRADkneedragger - 18-01-2009, 04:20am
RE: Hello from HeavyBusRacing - by SRADkneedragger - 18-01-2009, 04:33am
RE: Hello from HeavyBusRacing - by SRADkneedragger - 18-01-2009, 04:42am
RE: Hello from HeavyBusRacing - by Taubusa - 18-01-2009, 05:43am
RE: Hello from HeavyBusRacing - by Maj - 18-01-2009, 07:35am
RE: Hello from HeavyBusRacing - by BUSGO - 18-01-2009, 07:40am
RE: Hello from HeavyBusRacing - by GCBusa - 18-01-2009, 08:17am
RE: Hello from HeavyBusRacing - by LOAFIE - 18-01-2009, 08:32am
RE: Hello from HeavyBusRacing - by arthur dunga - 18-01-2009, 09:02am
RE: Hello from HeavyBusRacing - by Mutha - 18-01-2009, 09:03am
RE: Hello from HeavyBusRacing - by SRADkneedragger - 18-01-2009, 09:06am
RE: Hello from HeavyBusRacing - by LOAFIE - 18-01-2009, 12:29pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 18-01-2009, 09:08am
RE: Hello from HeavyBusRacing - by Ward P - 18-01-2009, 09:21am
RE: Hello from HeavyBusRacing - by SRADkneedragger - 18-01-2009, 09:46am
RE: Hello from HeavyBusRacing - by Slade - 18-01-2009, 10:42am
RE: Hello from HeavyBusRacing - by cAstAgeAr - 18-01-2009, 10:20am
RE: Hello from HeavyBusRacing - by SRADkneedragger - 18-01-2009, 10:46am
RE: Hello from HeavyBusRacing - by SRADkneedragger - 18-01-2009, 10:54am
RE: Hello from HeavyBusRacing - by Slade - 18-01-2009, 11:35am
RE: Hello from HeavyBusRacing - by SRADkneedragger - 18-01-2009, 11:39am
RE: Hello from HeavyBusRacing - by BUSGO - 18-01-2009, 12:21pm
RE: Hello from HeavyBusRacing - by bigfoot - 18-01-2009, 03:09pm
RE: Hello from HeavyBusRacing - by Volvi - 18-01-2009, 10:59pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 02-02-2009, 12:01pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 02-02-2009, 12:28pm
RE: Hello from HeavyBusRacing - by BUSGO - 02-02-2009, 02:23pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 02-02-2009, 02:38pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 13-02-2009, 02:45pm
RE: Hello from HeavyBusRacing - by cheeky - 13-02-2009, 06:14pm
RE: Hello from HeavyBusRacing - by bigfoot - 13-02-2009, 07:06pm
RE: Hello from HeavyBusRacing - by cheeky - 13-02-2009, 08:05pm
RE: Hello from HeavyBusRacing - by bigfoot - 13-02-2009, 08:38pm
RE: Hello from HeavyBusRacing - by cheeky - 13-02-2009, 10:24pm
RE: Hello from HeavyBusRacing - by bigfoot - 14-02-2009, 12:49pm
RE: Hello from HeavyBusRacing - by cheeky - 14-02-2009, 04:55pm
RE: Hello from HeavyBusRacing - by bigfoot - 15-02-2009, 08:31am
RE: Hello from HeavyBusRacing - by cheeky - 14-02-2009, 05:01pm
RE: Hello from HeavyBusRacing - by bigfoot - 15-02-2009, 08:32am
RE: Hello from HeavyBusRacing - by SRADkneedragger - 15-02-2009, 10:49am
RE: Hello from HeavyBusRacing - by bigfoot - 15-02-2009, 10:56am
RE: Hello from HeavyBusRacing - by SRADkneedragger - 15-02-2009, 11:10am
RE: Hello from HeavyBusRacing - by Vellaterra - 15-02-2009, 11:42am
RE: Hello from HeavyBusRacing - by BUSGO - 15-02-2009, 04:01pm
RE: Hello from HeavyBusRacing - by cheeky - 15-02-2009, 05:37pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 16-02-2009, 01:47am
RE: Hello from HeavyBusRacing - by cheeky - 16-02-2009, 05:51pm
RE: Hello from HeavyBusRacing - by cheeky - 16-02-2009, 08:56pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 02-03-2009, 06:53am
RE: Hello from HeavyBusRacing - by cheeky - 02-03-2009, 12:02pm
RE: Hello from HeavyBusRacing - by Scilaci - 02-03-2009, 03:56pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 02-03-2009, 05:29pm
RE: Hello from HeavyBusRacing - by Ward P - 02-03-2009, 05:48pm
RE: Hello from HeavyBusRacing - by Missy_Moo - 06-03-2009, 04:15pm
RE: Hello from HeavyBusRacing - by BUSGO - 02-03-2009, 05:37pm
RE: Hello from HeavyBusRacing - by cheeky - 02-03-2009, 05:52pm
RE: Hello from HeavyBusRacing - by Ward P - 02-03-2009, 06:42pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 06-03-2009, 02:13pm
RE: Hello from HeavyBusRacing - by Raging - 06-03-2009, 04:30pm
RE: Hello from HeavyBusRacing - by Mutha - 06-03-2009, 06:56pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 02-04-2009, 09:32am
RE: Hello from HeavyBusRacing - by BUSGO - 02-04-2009, 09:35am
RE: Hello from HeavyBusRacing - by GRUNTMAX - 02-04-2009, 03:44pm
RE: Hello from HeavyBusRacing - by Krusty - 02-04-2009, 05:33pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 03-04-2009, 03:03pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 05-04-2009, 05:10am
RE: Hello from HeavyBusRacing - by SRADkneedragger - 08-06-2009, 04:17am
RE: Hello from HeavyBusRacing - by SRADkneedragger - 02-08-2009, 09:37am
RE: Hello from HeavyBusRacing - by bigfoot - 02-08-2009, 10:03am
RE: Hello from HeavyBusRacing - by SRADkneedragger - 03-08-2009, 02:44pm
RE: Hello from HeavyBusRacing - by bigfoot - 03-08-2009, 04:38pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 24-08-2009, 10:34am
RE: Hello from HeavyBusRacing - by SRADkneedragger - 31-08-2009, 05:11am
RE: Hello from HeavyBusRacing - by SRADkneedragger - 31-08-2009, 07:57am
RE: Hello from HeavyBusRacing - by Volvi - 31-08-2009, 10:39am
RE: Hello from HeavyBusRacing - by SRADkneedragger - 31-08-2009, 10:46am
RE: Hello from HeavyBusRacing - by arthur dunga - 31-08-2009, 03:40pm
RE: Hello from HeavyBusRacing - by Mutha - 31-08-2009, 06:57pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 01-09-2009, 11:35am
RE: Hello from HeavyBusRacing - by SRADkneedragger - 02-09-2009, 01:25pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 03-09-2009, 01:04pm
RE: Hello from HeavyBusRacing - by ohdear - 03-09-2009, 09:32pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 04-09-2009, 12:46pm
RE: Hello from HeavyBusRacing - by Missy_Moo - 03-09-2009, 01:17pm
RE: Hello from HeavyBusRacing - by bigfoot - 03-09-2009, 06:09pm
RE: Hello from HeavyBusRacing - by CeeJay07 - 03-09-2009, 09:08pm
RE: Hello from HeavyBusRacing - by bigfoot - 04-09-2009, 05:28pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 05-09-2009, 01:05pm
RE: Hello from HeavyBusRacing - by bigfoot - 05-09-2009, 01:15pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 05-09-2009, 01:41pm
RE: Hello from HeavyBusRacing - by bigfoot - 05-09-2009, 02:04pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 05-09-2009, 03:03pm
RE: Hello from HeavyBusRacing - by bigfoot - 05-09-2009, 08:49pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 07-09-2009, 04:43pm
RE: Hello from HeavyBusRacing - by ohdear - 07-09-2009, 05:01pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 08-09-2009, 11:35am
RE: Hello from HeavyBusRacing - by bigfoot - 08-09-2009, 04:58pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 01-10-2009, 11:52pm
RE: Hello from HeavyBusRacing - by bigfoot - 02-10-2009, 07:07am
RE: Hello from HeavyBusRacing - by SRADkneedragger - 03-10-2009, 01:15pm
RE: Hello from HeavyBusRacing - by Madmax - 03-10-2009, 05:03pm
RE: Hello from HeavyBusRacing - by Landmine - 06-10-2009, 12:23am
RE: Hello from HeavyBusRacing - by Volvi - 03-10-2009, 01:28pm
RE: Hello from HeavyBusRacing - by gggsxr11 - 03-10-2009, 02:39pm
RE: Hello from HeavyBusRacing - by motoplast - 03-10-2009, 05:25pm
RE: Hello from HeavyBusRacing - by CeeJay07 - 03-10-2009, 07:19pm
RE: Hello from HeavyBusRacing - by Heidi1 - 03-10-2009, 08:03pm
RE: Hello from HeavyBusRacing - by motoplast - 04-10-2009, 02:47pm
RE: Hello from HeavyBusRacing - by Heidi1 - 04-10-2009, 07:25pm
RE: Hello from HeavyBusRacing - by CeeJay07 - 03-10-2009, 08:35pm
RE: Hello from HeavyBusRacing - by GRUNTMAX - 03-10-2009, 10:30pm
RE: Hello from HeavyBusRacing - by cheeky - 03-10-2009, 10:52pm
RE: Hello from HeavyBusRacing - by GRUNTMAX - 03-10-2009, 11:40pm
RE: Hello from HeavyBusRacing - by Madmax - 03-10-2009, 11:42pm
RE: Hello from HeavyBusRacing - by Heidi1 - 04-10-2009, 11:18am
RE: Hello from HeavyBusRacing - by fasterfaster - 04-10-2009, 05:56pm
RE: Hello from HeavyBusRacing - by bigfoot - 04-10-2009, 06:30pm
RE: Hello from HeavyBusRacing - by Legend - 04-10-2009, 07:36pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 06-10-2009, 02:16pm
RE: Hello from HeavyBusRacing - by Maj - 06-10-2009, 04:32pm
RE: Hello from HeavyBusRacing - by bigfoot - 06-10-2009, 04:56pm
RE: Hello from HeavyBusRacing - by motoplast - 06-10-2009, 05:16pm
RE: Hello from HeavyBusRacing - by fasterfaster - 06-10-2009, 06:38pm
RE: Hello from HeavyBusRacing - by Landmine - 06-10-2009, 09:54pm
RE: Hello from HeavyBusRacing - by arthur dunga - 07-10-2009, 06:50am
RE: Hello from HeavyBusRacing - by Madmax - 07-10-2009, 07:05am
RE: Hello from HeavyBusRacing - by BUSGO - 07-10-2009, 05:27pm
RE: Hello from HeavyBusRacing - by Maj - 18-10-2009, 12:11pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 20-10-2009, 01:22pm
RE: Hello from HeavyBusRacing - by Missy_Moo - 20-10-2009, 07:48pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 19-04-2010, 05:27pm
RE: Hello from HeavyBusRacing - by bigfoot - 19-04-2010, 06:01pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 19-04-2010, 06:04pm
RE: Hello from HeavyBusRacing - by fasterfaster - 19-04-2010, 07:53pm
RE: Hello from HeavyBusRacing - by Maj - 19-04-2010, 09:02pm
RE: Hello from HeavyBusRacing - by fasterfaster - 19-04-2010, 09:27pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 20-04-2010, 06:41am
RE: Hello from HeavyBusRacing - by SRADkneedragger - 20-04-2010, 02:22pm
RE: Hello from HeavyBusRacing - by davegc - 20-04-2010, 10:09pm
RE: Hello from HeavyBusRacing - by fasterfaster - 20-04-2010, 02:34pm
RE: Hello from HeavyBusRacing - by SRADkneedragger - 21-04-2010, 04:52am
RE: Hello from HeavyBusRacing - by grumpy - 21-04-2010, 08:59pm
RE: Hello from HeavyBusRacing - by Landmine - 21-04-2010, 10:07pm



Users browsing this thread: 1 Guest(s)